2005-23-15: Airplane flight manual (AFM)

2005-23-15 British Aerospace Airbus Limited: Amendment 39-14373. Docket No. FAA-2005-22427; Directorate Identifier 2004-NM-263-AD. Effective Date (a) This AD becomes effective December 21, 2005. Affected ADs (b) None. Applicability (c) This AD applies to all British Aerospace Model BAC 1-11 200 and 400 series airplanes, certificated in any category. Unsafe Condition (d) This AD results from fuel system reviews conducted by the manufacturer. We are issuing this AD to ensure that the flightcrew and maintenance personnel are advised of procedures pertaining to the safety of the fuel system. These procedures are needed to prevent potential ignition sources inside the fuel system, which, in combination with flammable fuel vapors, could result in a fuel tank explosion and consequent loss of the airplane. Compliance (e) You are responsible for having the actions required by this AD performed within the compliance times specified, unless the actions have already been done. Airplane Flight Manual and Maintenance Program Revisions (f) Within 3 months after the effective date of this AD, do the actions specified in paragraphs (f)(1) and (f)(2) of this AD to improve the safety of the fuel system, in accordance with the Accomplishment Instructions of Airbus UK BAC One-Eleven Alert Service Bulletin 28-A-PM6057, Issue 1, dated May 10, 2004. (1) Revise the airplane flight manual to include the applicable amendments advising the flightcrew of appropriate procedures to check for proper operation of the fuel system, and to address tripped circuit breakers, failure of a fuel pump in flight, and operations in a low-fuel situation, as specified in Table 2 (under Section 4.11) of the service bulletin. Note 1: The actions required by paragraph (f)(1) of this AD may be done by inserting a copy of the applicable advance amendment bulletins (AABs) specified in Table 2 of Airbus UK BAC One-Eleven Alert Service Bulletin 28-A-PM6057, Issue 1, dated May 10, 2004, into the AFM. When information identical to that in the applicable AABs has been included in the general revisions of the AFM, the AABs no longer need to be inserted into the AFM. (2) Revise the FAA-approved maintenance program to include all repetitive maintenance tasks specified in Table 1 (under Section 4.10.2.) of the service bulletin. Then, thereafter, comply with the requirements of these maintenance tasks at the interval specified in Table 1 of the service bulletin; except for airplanes that operate fewer than a total of 1,250 flight hours per year, accomplish the requirements of these maintenance tasks at the earlier of the times specified in columns 2 and 3 of Table 1 of the service bulletin. Where Table 1 of the service bulletin specifies a repetitive interval in "hours," for the purposes of this AD, this means "flight hours." Any applicable corrective actions must be done before further flight. Note 2: After revising the maintenanceprogram to include the required periodic maintenance tasks according to paragraph (f)(2) of this AD, operators do not need to make a maintenance log entry to show compliance with this AD every time those maintenance tasks are accomplished thereafter. Alternative Methods of Compliance (AMOCs) (g)(1) The Manager, International Branch, ANM-116, Transport Airplane Directorate, FAA, has the authority to approve AMOCs for this AD, if requested in accordance with the procedures found in 14 CFR 39.19. (2) Before using any AMOC approved in accordance with Sec. 39.19 on any airplane to which the AMOC applies, notify the appropriate principal inspector in the FAA Flight Standards Certificate Holding District Office. Related Information (h) British airworthiness directive G-2004-0012, dated June 21, 2004, also addresses the subject of this AD. Material Incorporated by Reference (i) You must use Airbus UK BAC One-Eleven Alert Service Bulletin 28-A-PM6057, Issue 1, dated May 10, 2004, to perform the actions that are required by this AD, unless the AD specifies otherwise. The Director of the Federal Register approved the incorporation by reference of this document in accordance with 5 U.S.C. 552(a) and 1 CFR part 51. Contact British Aerospace, Service Support, Airbus Limited, P.O. Box 77, Bristol BS99 7AR, England, for a copy of this service information. You may review copies at the Docket Management Facility, U.S. Department of Transportation, 400 Seventh Street, SW., room PL-401, Nassif Building, Washington, DC; on the Internet at http://dms.dot.gov; or at the National Archives and Records Administration (NARA). For information on the availability of this material at the NARA, call (202) 741-6030, or go to http://www.archives.gov/federal_register/code_of_federal_regulations/ibr_locations.html .