2007-16-12: Circuit breakers

2007-16-12 Boeing: Amendment 39-15151. Docket No. FAA-2006-25326; Directorate Identifier 2006-NM-081-AD. \n\nEffective Date \n\n\t(a) This AD becomes effective September 13, 2007. \n\nAffected ADs \n\n\t(b) None. \n\nApplicability \n\n\t(c) This AD applies to the Boeing airplanes identified in paragraphs (c)(1) and (c)(2) of this AD, certificated in any category. \n\n\t(1) Model 757-200 series airplanes, as identified in Boeing Service Bulletin 757-24-0093, dated August 14, 2003. \n\n\t(2) Model 757-300 series airplanes, as identified in Boeing Service Bulletin 757-24-0094, dated April 17, 2003. \n\nUnsafe Condition \n\n\t(d) This AD results from an in-flight entertainment (IFE) systems review. We are issuing this AD to ensure that the flightcrew is able to turn off electrical power to the IFE system and other non-essential electrical systems through utility bus switches in the flight compartment. The flightcrew's inability to turn off power to the IFE system and other non-essential electrical systems during a non-normal or emergency situation could result in the inability to control smoke or fumes in the airplane flight deck or cabin. \n\nCompliance \n\n\t(e) You are responsible for having the actions required by this AD performed within the compliance times specified, unless the actions have already been done. \n\nInstallation of Circuit Breakers, Relays, and Wiring \n\n\t(f) Within 60 months after the effective date of this AD, do the applicable actions specified in paragraphs (f)(1) through (f)(6) of this AD, in accordance with the Accomplishment Instructions of Boeing Service Bulletin 757-24-0093, dated August 14, 2003 (for Model 757-200 series airplanes); or Boeing Service Bulletin 757-24- 0094, dated April 17, 2003 (for Model 757-300 series airplanes); as applicable. \n\n\t(1) For all airplanes: Change the wiring at the P5 and P11 panel assemblies in the flight compartment, at the P36 panel assembly in the forward cargo compartment, and at the P37 and P70 panel assemblies in the main electronics compartment. Install a new relay and relay connector, if applicable, at the P36 panel assembly and at the P37 panel assembly. \n\n\t(2) For Model 757-200 series airplanes identified as Group 1 in Boeing Service Bulletin 757-24-0093, dated August 14, 2003: Install new circuit breakers C3090 and C3089 at the P37 and P70 panel assemblies, respectively, in the main electronics compartment. \n\n\t(3) For Model 757-200 series airplanes identified as Groups 21 and 22 in Boeing Service Bulletin 757-24-0093, dated August 14, 2003: Replace circuit breaker C311 at the P31 panel assembly in the main electronics compartment with a higher-rated circuit breaker. \n\n\t(4) For Model 757-200 series airplanes identified as Groups 1 through 20 inclusive and 23 through 40 inclusive in Boeing Service Bulletin 757-24-0093, dated August 14, 2003: Replace circuit breakers C311 and C315 at the P31 and P32 panel assemblies, respectively, in the main electronics compartment with higher-rated circuit breakers. \n\n\t(5) For Model 757-300 series airplanes identified as Groups 1 and 4 in Boeing Service Bulletin 757-24-0094, dated April 17, 2003: Replace circuit breakers C311 and C315 at the P31 and P32 panel assemblies, respectively, in the main electronics compartment with higher-rated circuit breakers. \n\n\t(6) For Model 757-300 series airplanes identified as Groups 1, 2, and 3 in Boeing Service Bulletin 757-24-0094, dated April 17, 2003: Install new wires between the P5 panel assembly in the flight compartment and the P36 and P37 panel assemblies in the main electronics compartment. \n\nConcurrent Requirement for Certain Airplanes \n\n\t(g) For the Model 757-200 series airplanes identified as Groups 8, 9, 12, 15, 20, 21 through 32 inclusive, and 34 through 40 inclusive in Boeing Service Bulletin 757-24-0093, dated August 14, 2003, equipped with control module assembly, part number (P/N) 233N3209-1025, -1026, -1028, -1300, or -1302: Prior to or concurrently with accomplishing the actions specified in paragraph (f) of this AD, modify the wiring of the control module assembly for the electrical systems, by accomplishing all of the actions specified in the Accomplishment Instructions of Boeing Component Service Bulletin 233N3209-24-04, Revision 1, dated August 14, 2003, as applicable. \n\nCredit for Accomplishment of Previous Service Bulletin \n\n\t(h) Modification of the control module assembly, P/N 233N3209- 1025, -1300, or -1302, done before the effective date of this AD in accordance with Boeing Component Service Bulletin 233N3209-24-04, dated April 10, 2003, is acceptable for compliance with the requirements of paragraph (g) of this AD. \n\nAlternative Methods of Compliance (AMOCs) \n\n\t(i)(1) The Manager, Seattle Aircraft Certification Office, FAA, has the authority to approve AMOCs for this AD, if requested in accordance with the procedures found in 14 CFR 39.19. \n\n\t(2) To request a different method of compliance or a different compliance timefor this AD, follow the procedures in 14 CFR 39.19. Before using any approved AMOC on any airplane to which the AMOC applies, notify your appropriate principal inspector (PI) in the FAA Flight Standards District Office (FSDO), or lacking a PI, your local FSDO. \n\nMaterial Incorporated by Reference \n\n\t(j) You must use the service information listed Table 1 of this AD to perform the actions that are required by this AD, unless the AD specifies otherwise. The Director of the Federal Register approved the incorporation by reference of these documents in accordance with 5 U.S.C. 552(a) and 1 CFR part 51. Contact Boeing Commercial Airplanes, P.O. Box 3707, Seattle, Washington 98124-2207, for a copy of this service information. You may review copies at the FAA, Transport Airplane Directorate, 1601 Lind Avenue SW., Renton, Washington; or at the National Archives and Records Administration (NARA). For information on the availability of this material at NARA, call 202-741-6030, or go to: http://www.archives.gov/federal-register/cfr/ibr-locations.html . \n\n\tTable 1.--Material Incorporated by Reference\n\n\n\nService Information\nRevision Level\nDate\nBoeing Component Service Bulletin 233N3209-24-04\n1\nAugust 14, 2003\nBoeing Service Bulletin 757-24-0093\nOriginal\nAugust 14, 2003\nBoeing Service Bulletin 757-24-0094\nOriginal\nApril 17, 2003