Ayres S2R-600 accident near Childress, Texas, June 1, 2006
On June 1, 2006 at about 6:06 pm local time, a Ayres S2R-600, registered N70AF, was substantially damaged in an accident near Childress, Texas (Childressmunicipal Airport). It was an aerial application (crop spraying) flight under agricultural flying rules (Part 137). No one was hurt; 1 person was on board or involved. The weather was visual conditions (good weather).
The NTSB's probable cause their words, unchanged
The pilot's inability to maintain directional control while landing due to the failure of the rudder horn due to corrosion.
Source: NTSB aviation accident database, copy made October 5, 2026. Docket and reports at the NTSB.
What the record shows
- Date
- June 1, 2006 · about 6:06 pm local time
- Place
- Childress, Texas · Childressmunicipal Airport · map
- Type
- Accident
- Injuries
- No one was hurt; 1 person was on board or involved.
- Weather
- visual conditions (good weather)
- Aircraft
- Ayres S2R-600
- Registration
- N70AF · registry record · serial 2547R
- Damage
- Substantial damage
- Flight
- Aerial application (crop spraying) flight · agricultural flying rules (Part 137)
The NTSB's narrative final · quoted from the NTSB record
While in cruise flight, the 19,620-hour commercial pilot lost control of the rudder pedals and experienced trouble maintaining directional control of the single-engine, turbine powered agricultural airplane. The pilot reported that "he dumped his chemical load at a safe location" and elected to discontinue the aerial application flight. The pilot proceed to a larger airport for a landing. The pilot added that he made several attempts to land as he was having trouble keeping the airplane aligned with runway 35 unless he maintained a much higher than normal airspeed on final approach. On his final attempt, the pilot was able to land, but as the airplane slowed down, it veered off the right side of the 5,949-foot long, by 75-foot wide asphalt runway. Following the loss of control, the left wing of the airplane collided with a tractor. A Federal Aviation Administration (FAA) safety inspector performed an on-scene examination of the airplane and found that the rudder horn was corroded and had completely separated. According to the pilot, the rudder horn is covered by fabric and it was difficult to inspect during a preflight inspection. The pilot added that even though the operator has a procedure in place to wash the airplane after spraying corrosive chemicals, he suggested that somehow chemicals had made contact with the rudder horn which caused the corrosion. At the time of the last 100 hour inspection, which was completed less than 11 days prior to the mishap, the tailwheel-equipped airplane had accumulated a total of 11,107.8 hours since new. The wind at the time of the accident was reported from 030 degrees at 8 knots.
The complete narrative as the NTSB published it. The NTSB's docket holds the report as a PDF and any photographs, statements and other documents from the investigation.
The factual record from the NTSB's investigation tables, in plain English
Pilot
- Certificate: commercial pilot
- Ratings: single-engine land
- Flight time: 19,620 hours in all; 2,540 in this make and model; 120 in the last 90 days; 45 in the last 30 days
- Medical certificate: Class 2
- Injury: no injuries
The aircraft
- Landing gear: fixed
- Engine: Garrett TPE-331 (piston); 0 hours total
The flight
- Departed from: 3F6 Paducah TX
- Destination: CDS Childress TX
- Flight plan: none
- Runway 040
Weather at the time
- Light: daylight
- Wind: from 030° at 8 knots
- Visibility: 10 statute miles
- Sky: clear
- Temperature: 81°F (27°C), dew point 57°F (14°C)
- Altimeter: 30.19 inHg
- Observation at 12:53 pm from CDS
Injuries
| Fatal | Serious | Minor | None | |
|---|---|---|---|---|
| Crew | 1 |
Documents from the investigation the NTSB's docket: the evidence folder behind the report
The docket, the folder of records gathered during an investigation (maintenance records, photographs, witness statements, examinations), has not been read from the NTSB for this case yet; the list appears here once it has. Open the docket at the NTSB.
Everything on this page comes from the NTSB's public records. The narrative, probable cause and findings are the NTSB's own words; the coded tables behind the report are written out in plain English, with pilots' ages, home towns and medical details left out. The documents and photographs are the NTSB's docket, shown as the NTSB released them. This site's own text never names anyone involved. A preliminary report can change; the final report usually follows one to two years later, and the page is refreshed when it does.