2022-18-03: Windshield/Door Rain/Ice Removal

1. The authority citation for part 39 continues to read as follows: Authority: 49 U.S.C. 106(g), 40113, 44701. 2. The FAA amends § 39.13 by: a. Removing Airworthiness Directive 2022-05-13, Amendment 39-21965 (87 FR 14155, March 14, 2022); and b. Adding the following new airworthiness directive: 2022-18-03 Honda Aircraft Company LLC: Amendment 39-22154; Docket No. FAA-2022-1057; Project Identifier AD-2022-00526-A. (a) Effective Date This airworthiness directive (AD) is effective September 22, 2022. (b) Affected ADs This AD replaces AD 2022-05-13, Amendment 39-21965 (87 FR 14155, March 14, 2022) (AD 2022-05-13). (c) Applicability This AD applies to Honda Aircraft Company LLC Model HA-420 airplanes, serial numbers 42000011 through 42000179, 42000182, and 42000187, certificated in any category, with a windshield assembly installed that has a part number and serial number listed in table 5 of the Accomplishment Instructions in Honda Aircraft Company Alert Service Bulletin SB-420-56-002, Revision B, dated April 19, 2021 (Honda SB-420-56-002, Revision B). (d) Subject Joint Aircraft System Component (JASC) Code 3040, Windshield/Door Rain/Ice Removal. (e) Unsafe Condition This AD was prompted by a report of in-flight smoke and fire that initiated from the windshield heat power wire braid. The FAA is issuing this AD to prevent arcing of the windshield heat power wire braid, which could ignite the wire sheathing and sealant and the windshield acrylic. This condition, if not addressed, could lead to cockpit smoke and fire. (f) Compliance Comply with this AD within the compliance times specified, unless already done. (g) Temporary Revisions to the Airplane Flight Manuals (AFMs) and Quick Reference Handbooks (QRHs) (1) Within 15 days after the effective date of this AD, revise the existing AFM and QRH for your airplane by inserting the pages identified in the applicable temporary revisions listed in paragraphs (g)(1)(i) through (iv) of this AD. (i) Honda Aircraft Company Temporary Revision TR 04A-1, dated 2020, for Airplane Flight Manual HJ1-29001-003-001 Rev C. (ii) HondaJet Temporary Revision TR 04A-1, dated 2020, for Quick Reference Handbook HJ1-29000-007-001 Rev C. (iii) Honda Aircraft Company Temporary Revision TR 04A-1, dated 2020, for Airplane Flight Manual HJ1-29001-003-001 Rev E. (iv) HondaJet Temporary Revision TR 04A-1, dated 2020, for Quick Reference Handbook Normal Procedures, HJ1-29001-007-001 Rev E. (2) The actions required by paragraph (g)(1) of this AD may be performed by the owner/operator (pilot) holding at least a private pilot certificate and must be entered into the aircraft records showing compliance with this AD in accordance with 14 CFR 43.9(a)(1) through (4), and 14 CFR 91.417(a)(2)(v). The record must be maintained as required by 14 CFR 91.417, 121.380, or 135.439. (h) Windshield Assembly Replacement Within 24 months after April 18, 2022 (the effective date of AD 2022-05-13), for each windshield assembly with a part number and serial number listed in table 5 of the Accomplishment Instructions in Honda SB-420-56-002, Revision B, replace the windshield assembly in accordance with step (2) or (3) of the Accomplishment Instructions in Honda SB-420-56-002, Revision B. (i) Removal of Revisions to the AFMs and QRHs Before further flight after replacing the windshield assemblies required by paragraph (h) of this AD, remove the AFM and QRH pages that were required by paragraph (g) of this AD. (j) Alternative Methods of Compliance (AMOCs) (1) The Manager, Atlanta ACO Branch, FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. In accordance with 14 CFR 39.19, send your request to your principal inspector or local Flight Standards District Office, as appropriate. If sending information directly to the manager of the certification office, send it to the attention of the person identified in paragraph (k) of this AD. (2) Before using any approved AMOC, notify your appropriate principal inspector, or lacking a principal inspector, the manager of the local flight standards district office/certificate holding district office. (3) AMOCs approved previously in accordance with AD 2022-05-13 are approved as AMOCs for the corresponding requirements in paragraph (g) of this AD. (4) For service information that contains steps that are labeled as "Required for Compliance" (RC), the following provisions apply. (i) The steps labeled as RC, including substeps under an RC step and any figures identified in an RC step, must be done to comply with the AD. An AMOC is required for any deviations to RC steps, including substeps and identified figures. (ii) Steps not labeled as RC may be deviated from using accepted methods in accordance with the operator's maintenance or inspection program without obtaining approval of an AMOC, provided the RC steps, including substeps and identified figures, can still be done as specified, and the airplane can be put back in an airworthy condition. (k) Related Information For more information about this AD, contact Bryan Long, Aviation Safety Engineer, Atlanta ACO Branch, FAA, 1701 Columbia Avenue, College Park, GA 30337; phone: (404) 474-5578; email: 9-ASO-ATLACO-ADs@faa.gov. (l) Material Incorporated by Reference (1) The Director of the Federal Register approved the incorporation by reference (IBR) of the service information listed in this paragraph under 5 U.S.C. 552(a) and 1 CFR part 51. (2) You must use this service information as applicable to do the actions required by this AD, unless the AD specifies otherwise. (3) The following service information was approved for IBR on September 22, 2022. (i) Honda Aircraft Company Temporary Revision TR 04A-1, dated 2020, for Airplane Flight Manual HJ1-29000-003-001 Rev E. (ii) Honda Aircraft Company Temporary Revision TR 04A-1, dated 2020, for Airplane Flight Manual HJ1-29001-003-001 Rev C. (iii) HondaJet Temporary Revision TR 04A-1, dated 2020, for Quick Reference Handbook HJ1-29000-007-001 Rev E. (iv) HondaJet Temporary Revision TR 04A-1, dated 2020, for Quick Reference Handbook HJ1-29001-007-001 Rev C. (4) The following service information was approved for IBR on April 18, 2022 (87 FR 14155, March 14, 2022). (i) Honda Aircraft Company Alert Service Bulletin SB-420-56-002, Revision B, dated April 19, 2021. (ii) [Reserved] (5) For service information identified in this AD, contact Honda Aircraft Company LLC, 6430 Ballinger Road, Greensboro, NC 27410; phone: (336) 662-0246; website: hondajet.com. (6) You may view this service information at FAA, Airworthiness Products Section, Operational Safety Branch, 901 Locust, Kansas City, MO 64106. For information on the availability of this material at the FAA, call (817) 222-5110. (7) You may view this service information that is incorporated by reference at the National Archives and Records Administration (NARA). For information on the availability of this material at NARA, email: fr.inspection@nara.gov, or go to: archives.gov/federal-register/cfr/ibr-locations.html. Issued on August 17, 2022. Christina Underwood, Acting Director, Compliance & Airworthiness Division, Aircraft Certification Service. [FR Doc. 2022-19021 Filed 9-1-22; 8:45 am]BILLING CODE 4910-13-P