Mooney M20-J accident near Renton, Washington, July 4, 2003
On July 4, 2003 at about 6:18 pm local time, a Mooney M20-J, registered N201DV, was substantially damaged in an accident near Renton, Washington (Renton Muni airport). It was a personal flight under general aviation rules (Part 91). No one was hurt; 3 people were on board or involved. The weather was visual conditions (good weather).
The NTSB's probable cause their words, unchanged
In-flight failure of the electric landing gear motor during the initial takeoff climb.
Source: NTSB aviation accident database, copy made October 5, 2026. Docket and reports at the NTSB.
What the record shows
- Date
- July 4, 2003 · about 6:18 pm local time
- Place
- Renton, Washington · Renton Muni · map
- Type
- Accident
- Injuries
- No one was hurt; 3 people were on board or involved.
- Weather
- visual conditions (good weather)
- Aircraft
- Mooney M20-J · all M20-Js on the register
- Registration
- N201DV · registry record · serial 24-0088
- Damage
- Substantial damage
- Flight
- Personal flight · general aviation rules (Part 91)
The NTSB's narrative final · quoted from the NTSB record
The pilot reported that the airplane experienced an electrical malfunction 2-3 minutes after takeoff. After multiple unsuccessful attempts to reset the electrical system, the pilot attempted to manually lower the landing gear in preparation for a landing. He reported that he was able to actuate the manual gear extension handle, however, the landing gear would not fully extend and lock. After multiple additional attempts to fully lower the gear, the pilot initiated a landing with the main landing gear in the midrange position. Examination of the landing gear system by representatives from the NTSB and FAA revealed that the landing gear actuator housing fractured, and separated from the gearbox. Damage was also noted to the actuator drive coupling. Representatives from the FAA and the manufacturer of the gear assembly conducted the teardown and examination of the electric landing gear actuator motor. During the examination, 14 volts was applied to the actuator motor in an attempt to functionally test the DC motor. The electric motor did not respond, or draw current. Further examination of the motor revealed that the two brushes in the motor were of dissimilar type and design and showed signs of arcing. Additionally, the motors armature showed signs of severe wear. Logbook records indicated that the electric landing gear motor was serviced on February 1, 2001, approximately 39 flight hours prior to the accident. The log entry indicated that the armature shaft and brushes were replaced and that the gear motor was returned to service.
The complete narrative as the NTSB published it. The NTSB's docket holds the report as a PDF and any photographs, statements and other documents from the investigation.
The factual record from the NTSB's investigation tables, in plain English
Pilot
- Certificate: commercial pilot
- Ratings: multi-engine land; single-engine land; instrument: airplane
- Flight time: 985 hours in all; 700 in this make and model; 4 in the last 90 days; 1 in the last 30 days; 780 as pilot in command; 16 on instruments
- Last flight review: September 7, 2001
- Medical certificate: Class 2
- Seat: left
- Injury: no injuries
The aircraft
- Airframe total time: 2,263 hours
- Last inspection: annual inspection, August 7, 2002; 15 hours since
- Maximum gross weight: 2,740 lb
- Seats: 4
- Landing gear: retractable
- Engine: Lycoming IO-360 (piston); 0 hours total
The flight
- Departed from: RNT Renton WA at 5:30 pm
- Destination: RNT Renton WA
- Flight plan: none
- Runway 33, 5,382 ft by 200 ft
Weather at the time
- Light: daylight
- Wind: from 350° at 7 knots
- Visibility: 10 statute miles
- Sky: clear
- Temperature: 70°F (21°C), dew point 52°F (11°C)
- Altimeter: 30.14 inHg
- Observation at 6:53 pm from KRNT
Injuries
| Fatal | Serious | Minor | None | |
|---|---|---|---|---|
| Crew | 1 | |||
| Passengers | 2 |
Documents from the investigation the NTSB's docket: the evidence folder behind the report
The docket, the folder of records gathered during an investigation (maintenance records, photographs, witness statements, examinations), has not been read from the NTSB for this case yet; the list appears here once it has. Open the docket at the NTSB.
Everything on this page comes from the NTSB's public records. The narrative, probable cause and findings are the NTSB's own words; the coded tables behind the report are written out in plain English, with pilots' ages, home towns and medical details left out. The documents and photographs are the NTSB's docket, shown as the NTSB released them. This site's own text never names anyone involved. A preliminary report can change; the final report usually follows one to two years later, and the page is refreshed when it does.