Grumman G-164B accident near Basin City, Washington, May 16, 2003
On May 16, 2003 at about 8:00 pm local time, a Grumman G-164B, registered N3629E, was substantially damaged in an accident near Basin City, Washington. It was an aerial application (crop spraying) flight under agricultural flying rules (Part 137). No one was hurt; 1 person was on board or involved. The weather was visual conditions (good weather).
The NTSB's probable cause their words, unchanged
The failure of the torque sensor idler gear duplex bearing during agricultural aerial application, resulting in a total power loss and a forced landing. Factors include tall wheat and soft terrain.
Source: NTSB aviation accident database, copy made October 5, 2026. Docket and reports at the NTSB.
What the record shows
- Date
- May 16, 2003 · about 8:00 pm local time
- Place
- Basin City, Washington · map
- Type
- Accident
- Injuries
- No one was hurt; 1 person was on board or involved.
- Weather
- visual conditions (good weather)
- Aircraft
- Grumman G-164B · all G-164Bs on the register
- Registration
- N3629E · no longer on the register · serial 744B
- Damage
- Substantial damage
- Flight
- Aerial application (crop spraying) flight · agricultural flying rules (Part 137)
The NTSB's narrative final · quoted from the NTSB record
The pilot had just executed a reversal turn in order to start another spraying swath when the turbine engine suddenly stopped and the propeller feathered. He attempted to land on a road near the edge of the field he was spraying, but a tractor was on the road so he had to land in a crop of tall wheat. Just before touchdown, one of the aircraft's wings impacted the terrain, and during the landing roll on the soft terrain, the aircraft nosed over. During a post-accident teardown inspection it was determined that the torque sensor idler gear duplex bearing (part number 3103035-1) had failed, which is a condition that would normally result in an uncommanded in-flight shutdown of the engine. Further inspection of the bearing revealed only minimal heat stress discoloration and no clear lack of lubrication, but the bearing balls had been worn undersize, and the bearing cage had fractured into pieces. Further inspection of the bearing by Honeywell Mechanical Systems, revealed that the bearing condition was consistent with advanced rolling contact fatigue failure. As part of the investigation, an FAA Airworthiness Inspector determined that, "The installation of the subject matched bearing set was performed properly by the last overhaul shop in accordance with the Allied-Signal (Honeywell) Overhaul Specification No. 72-00-17, revised July 20, 1992." Although the reason for the unexpected failure of this bearing after approximately 100 hours of operation could not be determined, it was noted that at the last overhaul, the Torque Sensor was not upgraded to the available -3 bearing, which uses a larger bearing assembly and a different gear set.
The complete narrative as the NTSB published it. The NTSB's docket holds the report as a PDF and any photographs, statements and other documents from the investigation.
The factual record from the NTSB's investigation tables, in plain English
Pilot
- Certificate: commercial pilot
- Ratings: single-engine land
- Flight time: 15,000 hours in all; 100 in the last 90 days
- Medical certificate: Class 2 (valid medical--no waivers/lim.)
- Seat: frt
- Injury: no injuries
The aircraft
- Seats: 1
- Landing gear: fixed
- Engine: Garrett-Airesearch TPE-331-2-201 (turboprop); 0 hours total
The flight
- Departed from: Basin City WA at 7:45 pm
- Flight plan: none
Weather at the time
- Light: daylight
- Visibility: 10 statute miles
- Sky: clear
- Temperature: 70°F (21°C), dew point 0°F (-18°C)
Injuries
| Fatal | Serious | Minor | None | |
|---|---|---|---|---|
| Crew | 1 |
Documents from the investigation the NTSB's docket: the evidence folder behind the report
The docket, the folder of records gathered during an investigation (maintenance records, photographs, witness statements, examinations), has not been read from the NTSB for this case yet; the list appears here once it has. Open the docket at the NTSB.
Other NTSB records under N3629E the same tail number, which may have belonged to a different aircraft at the time
Everything on this page comes from the NTSB's public records. The narrative, probable cause and findings are the NTSB's own words; the coded tables behind the report are written out in plain English, with pilots' ages, home towns and medical details left out. The documents and photographs are the NTSB's docket, shown as the NTSB released them. This site's own text never names anyone involved. A preliminary report can change; the final report usually follows one to two years later, and the page is refreshed when it does.