Piper PA-32RT-300T accident near Baker, California, September 8, 1992
On September 8, 1992 at about 8:10 pm local time, a Piper PA-32RT-300T, registered N20926, was destroyed in an accident near Baker, California. It was a personal flight under general aviation rules (Part 91). 1 person had minor injuries; 1 other was unhurt. The weather was visual conditions (good weather).
The NTSB's probable cause their words, unchanged
THE UNKNOWN PILOTS IMPROPER USE OF THE THROTTLES WHICH RESULTED IN THE OVERBOOSTING OF THE ENGINE. CONTRIBUTING TO THE ACCIDENT WAS THE MAINTENANCE PERSONNEL IMPROPER MAINTENANCE IN ADJUSTING THE TURBOCHARGER WASTEGATE AND THE OIL LEAKING FROM THE ENGINE AFTER THE CATASTROPHIC FAILURE WHICH RESTRICTED THE PILOT'S VISUAL OUTLOOK.
Source: NTSB aviation accident database, copy made October 5, 2026. Docket and reports at the NTSB.
What the record shows
- Date
- September 8, 1992 · about 8:10 pm local time
- Place
- Baker, California · map
- Type
- Accident
- Injuries
- 1 person had minor injuries; 1 other was unhurt.
- Weather
- visual conditions (good weather)
- Aircraft
- Piper PA-32RT-300T PA-32RT-30 · all PA-32RT-300Ts on the register
- Registration
- N20926 · no longer on the register · serial 32R-7887181
- Damage
- Destroyed
- Flight
- Personal flight · general aviation rules (Part 91)
The NTSB's narrative final · quoted from the NTSB record
A PIPER 32RT 300T, LANDED HARD ON DIRT STRIP AFTER EXPERIENCING A TOTAL LOSS OF ENGINE POWER. THE PILOT HEARD A LOUD BANG WHILE CRUISING AT 13,500 MSL. OIL FROM THE ENGINE OBSCURED THE PILOT'S VISION THROUGH THE WINDSHIELD. THE PILOT SECURED THE ENGINE AND SELECTED A DIRT STRIP NEAR AN AUTOMOBILE SALVAGE YARD AS A FORCED LANDING AREA. DURING THE LANDING THE AIRPLANE STRUCK AN AUTOMOBILE. SAFETY BOARD INVESTIGATORS FOUND A HOLE IN THE ENGINE CRANKCASE IN THE VICINITY OF THE NUMBER 1 AND NUMBER 2 CYLINDERS DURING THE PRELIMINARY EXAMINATION. DISASSEMBLY OF THE ENGINE REVEALED THE NUMBERS 1 AND 2 CONNECTING RODS WERE BROKEN AND THE NUMBER 1 CONNECTING ROD CONTAINED A GALLED SPOT ON ITS CONNECTING ROD BEARING SURFACE. SUBSEQUENT EXAMINATION OF THE FIVE REMAINING CONNECTING RODS REVEALED EVIDENCE OF GALLING BETWEEN THE CONNECTING ROD BEARING FACE AND ROD BEARING. ACCORDING TO THE ENGINE MANUFACTURER, GALLING BETWEEN THE CONNECTING ROD BEARING FACE AND ROD BEARING IS CAUSED BY PERIODS OF HIGH LOADING DUE TO OVERSPEED OR EXCESSIVE MANIFOLD PRESSURE. ABOUT 15 DAYS OR 6 FLIGHT HOURS, THE TURBOCHARGER WASTEGATE WAS ADJUSTED BY MAINTENANCE PERSONNEL. THE PILOT INDICATED THAT THERE WERE NO UNUSUAL INSTRUMENT INDICATIONS BEFORE THE ENGINE FAILURE.
The complete narrative as the NTSB published it. The NTSB's docket holds the report as a PDF and any photographs, statements and other documents from the investigation.
The factual record from the NTSB's investigation tables, in plain English
Pilot
- Certificate: flight instructor, commercial pilot
- Ratings: multi-engine land; single-engine land; instructor: airplane multi-engine; instructor: airplane single-engine; instrument: airplane
- Flight time: 7,601 hours in all; 256 in this make and model; 12 in the last 90 days; 11 in the last 30 days; 7,000 as pilot in command; 1,391 on instruments
- Medical certificate: Class 2 (valid medical--w/ waivers/lim.)
- Seat: left
The aircraft
- Airframe total time: 2,047 hours
- Last inspection: annual inspection, February 5, 1992; 30 hours since
- Maximum gross weight: 3,600 lb
- Seats: 6
- Landing gear: retractable
- Engine: Lycoming TIO-540-S1AD (piston); 0 hours total
The flight
- Departed from: BUR Burbank CA at 7:00 pm
- Destination: SLC Salt Lake City UT
- Flight plan: VFR
- Runway 0
- A second pilot was aboard
Weather at the time
- Light: daylight
- Wind: from 300° at 10 knots
- Visibility: 50 statute miles
- Sky: scat at 25,000 ft
- Temperature: 95°F (35°C), dew point 39°F (4°C)
- Altimeter: 29.00 inHg
- Observation at 8:52 pm from DAG, 43 miles away
Injuries
| Fatal | Serious | Minor | None | |
|---|---|---|---|---|
| Crew | 1 | |||
| Passengers | 1 |
Documents from the investigation the NTSB's docket: the evidence folder behind the report
The docket, the folder of records gathered during an investigation (maintenance records, photographs, witness statements, examinations), has not been read from the NTSB for this case yet; the list appears here once it has. Open the docket at the NTSB.
Everything on this page comes from the NTSB's public records. The narrative, probable cause and findings are the NTSB's own words; the coded tables behind the report are written out in plain English, with pilots' ages, home towns and medical details left out. The documents and photographs are the NTSB's docket, shown as the NTSB released them. This site's own text never names anyone involved. A preliminary report can change; the final report usually follows one to two years later, and the page is refreshed when it does.