Piper PA-25-235 accident near Flagler, Colorado, May 22, 2004
On May 22, 2004 at about 4:30 pm local time, a Piper PA-25-235, registered N8586L, was substantially damaged in an accident near Flagler, Colorado. It was an aerial application (crop spraying) flight under agricultural flying rules (Part 137). No one was hurt; 1 person was on board or involved. The weather was visual conditions (good weather).
The NTSB's probable cause their words, unchanged
the pilot's improper in-flight planning/decision which led to fuel exhaustion and subsequent loss of engine power. Factors contributing to the accident were the low altitude, low airspeed, and the inoperative fuel quantity gauge.
Source: NTSB aviation accident database, copy made October 5, 2026. Docket and reports at the NTSB.
What the record shows
- Date
- May 22, 2004 · about 4:30 pm local time
- Place
- Flagler, Colorado · map
- Type
- Accident
- Injuries
- No one was hurt; 1 person was on board or involved.
- Weather
- visual conditions (good weather)
- Aircraft
- Piper PA-25-235 · all PA-25-235s on the register
- Registration
- N8586L · no longer on the register · serial 25-5010
- Damage
- Substantial damage
- Flight
- Aerial application (crop spraying) flight · agricultural flying rules (Part 137)
The NTSB's narrative final · quoted from the NTSB record
The pilot said he was aerial spraying 15 miles south of Flagler, Colorado. He said he refueled the airplane the load before the accident with 15 to 20 gallons of fuel. The pilot reported his bubble fuel gage indicated he had 10 to 15 gallons of fuel. The pilot said he was in a turn, reversing course to make his last pass on a field before returning to the airstrip. About 200 feet above the ground, the engine lost power. The pilot said he leveled the wings, put the nose down, and thought he would be okay. He said however, he had no airspeed to flare and hit the ground hard. The airplane's main landing gear and right wing were broken aft. The pilot said he was "100 percent certain" that he ran out of fuel. An examination of the airplane revealed no anomalies.
The complete narrative as the NTSB published it. The NTSB's docket holds the report as a PDF and any photographs, statements and other documents from the investigation.
The factual record from the NTSB's investigation tables, in plain English
Pilot
- Certificate: commercial pilot
- Ratings: multi-engine land; single-engine land
- Flight time: 6,100 hours in all; 100 in this make and model; 10 in the last 90 days; 10 in the last 30 days
- Medical certificate: Class 2
- Injury: no injuries
The aircraft
- Landing gear: fixed
- Engine: Lycoming O-540-B2C5 (piston); 0 hours total
The flight
- Departed from: Flagler CO at 4:00 pm
- Flight plan: none
Weather at the time
- Light: daylight
- Temperature: 0°F (-18°C), dew point 0°F (-18°C)
Injuries
| Fatal | Serious | Minor | None | |
|---|---|---|---|---|
| Crew | 1 |
Documents from the investigation the NTSB's docket: the evidence folder behind the report
The docket, the folder of records gathered during an investigation (maintenance records, photographs, witness statements, examinations), has not been read from the NTSB for this case yet; the list appears here once it has. Open the docket at the NTSB.
Everything on this page comes from the NTSB's public records. The narrative, probable cause and findings are the NTSB's own words; the coded tables behind the report are written out in plain English, with pilots' ages, home towns and medical details left out. The documents and photographs are the NTSB's docket, shown as the NTSB released them. This site's own text never names anyone involved. A preliminary report can change; the final report usually follows one to two years later, and the page is refreshed when it does.